Catalina - Capri - 25s International Assocaition Logo(2006)  
Assn Members Area · Join
h.jpg Home.
a.jpg Association Forum
s.jpg Ships Store
c.jpg Cruising
r.jpg Racing
t.jpg Technical Tips
g.jpg Photo Gallery - New
o.jpg Boat Search - Updated
m.jpg Manuals & Brochures
3rdrpt.jpg Swap Meet
l.jpg Links
f.jpg Officer Flag Line & Staff
b.jpg Bylaws & Constitution
 
1.jpg Members Area
1.jpg Join the Association
 
Notice:
The advice given on this site is based upon individual or quoted experience, yours may differ.
The Officers, Staff and members of this site only provide information based upon the concept that anyone utilizing this information does so at their own risk and holds harmless all contributors to this site.
 
Association Forum
Association Forum
Home | Profile | Register | Active Topics | Forum Users | Search | FAQ
Username:
 Password:
Save Password
Forgot your Password?

 All Forums
 Catalina/Capri 25/250 Sailor's Forums
 Catalina 25 Specific Forum
 Fuel on port side		  New Topic  Reply to Topic
 Printer Friendly
Author Previous Topic Topic Next Topic  

Boomeroo
Navigator

Member Avatar

Australia
128 Posts
Initially Posted - 11/16/2020 :  01:21:35  Show Profile  Reply with Quote
Hi, My older SK has the fuel shelf in the port dumpster. I have it in a plastic container with a drain to the cockpit. But still vent and filling fumes escape.
What has been done to olderboats. I plan to put the 3 gallon tank in the aft of the cockpit and build a cover over it strong enough to stand on and insulated .
Any ideas or other solutions.
Graeme Bishop boomeroo Australia
C25 SK

islander
Master Marine Consultant

Members Avatar

USA
3992 Posts
Response Posted - 11/16/2020 :  12:24:57  Show Profile  Reply with Quote
Make sure the cover is well vented. Don't want fumes to build up inside.
Scott-"IMPULSE"87'C25/SR/WK/Din.#5688
Sailing out of Glen Cove,L.I Sound


Go to Top of Page

Derek Crawford
Master Marine Consultant

Members Avatar

USA
3312 Posts
Response Posted - 11/17/2020 :  09:00:57  Show Profile  Reply with Quote
I had the same setup on TSU. I always took the gas tank off the boat to refill it. When leaving the boat I always tightened down the vent cap, and was never bothered by fumes in the locker.
Derek Crawford
Chief Measurer C25-250 2008
Previous owner of "This Side UP"
1981 C-25 TR/FK #2262 Used to have an '89 C22 #9483, "Downsized"
San Antonio, Texas
Go to Top of Page

Voyager
Master Marine Consultant

Members Avatar

USA
5231 Posts
Response Posted - 11/17/2020 :  17:16:25  Show Profile  Reply with Quote
The regulations say that if you have an enclosed area on a boat where gasoline fumes are produced by a gas tank or engine carburetor then you need a positive ventilation system. Most inboard powerboats have two cowls and a blower controlled by a switch. You have to run the blower for a few minutes to clear the air.

Here’s an example:
https://www.westmarine.com/buy/west-marine--engine-blower-4--P013855028

My boat’s electrical panel backs up inside the dumpster beneath the cockpit. If the proper air-gas mixture collected inside the area and I flipped the switch, I’m certain that the boat would blow sky high. The blower would prevent that inconvenience, and I’d advise anyone with that problem to go ahead and install one.
Bruce Ross
Passage ~ SR-FK ~ C25 #5032

Port Captain — Milford, CT
Edited by - Voyager on 11/17/2020 17:25:57
Go to Top of Page

OLarryR
Master Marine Consultant

Members Avatar

USA
3367 Posts
Response Posted - 11/18/2020 :  07:02:37  Show Profile  Visit OLarryR's Homepage  Reply with Quote
I am not sure if this is doable but rather than build/install an insulated cover, perhaps check out portable plastic coolers that the 3 gallon tank can fit in. You could cut rectangular slots in the cooler to ventilate it similar to the slot in the cockpit cover of later model Catalinas.

Not sure why you need an "insulated" cover. Why not just build a free standing shelf and place in aft part of cockpit and slide the the 3 gallon tank underneath it. Oftentimes, I only store my 3 gallon tank in the starboard cockpit ventilated locker/cover. When I use it, I remove it from the locker and leave it aft adjacent to the transom. It's not an area I would be standing anyway, so I am okay with leaving the tank there when sailing. If I have someone sailing with me, I oftentimes rest the life vests on top of the gas tank - Just lays on top of the tank and does not interfere with the tank vent. I always wear a self inflatable preserver but always have the life vests in the cockpit and if sailing with more people, then those choosing not to wear a vest, I leave the other vests near the companionway.
Larry
'89 Robin's Nest#5820, Potomac River/Quantico, Va
http://catalina25.homestead.com/olarryr.html
Go to Top of Page

Boomeroo
Navigator

Members Avatar

Australia
128 Posts
Response Posted - 11/18/2020 :  21:01:33  Show Profile  Reply with Quote
Thanks for that . A shelf is better as will allow better air circulation and easier to fit . Tank in locker is well insulated from sun on 100 deg days so want ventilation and insulation if outside.
Graeme Bishop boomeroo Australia
C25 SK
Go to Top of Page
  Previous Topic Topic Next Topic  
 New Topic  Reply to Topic
 Printer Friendly
Jump To:
Association Forum © since 1999 Catalina Capri 25s International Association Go To Top Of Page
Powered By: Snitz Forums 2000 Version 3.4.06
Notice: The advice given on this site is based upon individual or quoted experience, yours may differ.
The Officers, Staff and members of this site only provide information based upon the concept that anyone utilizing this information does so at their own risk and holds harmless all contributors to this site.